 |
|
 |
 |
| INSTALLING SIDING | PREPARATION | RIGID
FOAM SHEATHING |
|
Applying Siding Over Rigid Foam Sheathing
Rigid foam sheathing has an insulation value superior to that of traditional lumber and plywood sheathings. However, it has little or no nail holding power and using rigid foam sheathing as a nailing base for cedar siding is not recommended. For best results with rigid foam and other sheathing products, follow the nailing recommendations as to nail type, positioning, penetration and spacing. The table below provides nail length recommendations for siding and foam sheathing systems.
Foam sheathing panels vary in moisture permeability but are generally considered as good moisture barriers. They should be used with a continuous film vapour retarder on the inside wall under the interior finish or with foil-backed gypsum board. Rigid foam sheathing can cause moisture to accumulate on the back of siding and cause staining, buckling and damage to finish coats. The following recommendations are meant to minimize potential problems when Cedar sidings are applied over rigid foam sheathing:
- Use thicker siding patterns in widths of 8" (203 mm) or less. Thick, narrow siding is more stable than thinner, wider patterns and better able to resist dimensional changes.
- Use kiln-dried siding over rigid foam sheathing. This is the most stable cedar siding.
- Proper prefinish is essential. Follow the priming recommendations given in this publication before installing siding.
- Use light color finish coats to maximize heat reflection and reduce dimensional movement.
- In severe climates, an air space between siding and rigid foam sheathing can be created by fastening furring strips to the sheathing before installing siding (see Wall Construction). Air spaces allow for the venting of accumulated moisture.
- In all cases it is recommended that building paper or an equivalent building wrap be applied over the foam sheathing.
Recommended Minimum Nail Length for Siding over Foam Sheathing
Siding and Sheathing Thicknesses |
Nail Length
|
| |
Inches |
Millimeter |
1/2" (13mm) siding and ½" (13mm) foam sheathing |
2-1/4 |
57mm |
1/2" (13mm) siding and ¾" (19mm) foam sheathing |
2-1/2 |
64mm |
1/2" (13mm) siding and 1" (25mm) foam sheathing |
3 |
76mm |
5/8" (16mm) or 3/4" (19mm) siding and 1/2" (13mm) foam sheathing |
2-1/2 |
64mm |
5/8" (16mm) or 3/4" (19mm) siding and 1" (25mm) foam sheathing |
3 |
76mm |
|
|
|
| |
|
|
| |
|
|
| |
 |
Members of the Western Red Cedar Export Association provide western red cedar to Belgium, France, The Netherlands, United Kingdom, Australia, New Zealand, China, Japan and other markets around the world. |
|
|
| |
|
|
| |
|
|
|
|
|
